ここから本文です
TWO:"Kip calm, ladkip calm. There's naun there, naun, I tell you."
Classification by type of system
1natural circulation external heating pipe type
2natural circulation calandria type
3forced circulation type
4falling-film type
5rising film type
6jacket type
7coil type
Classification by method of operation
1single effect evaporator system
2multiple effect evaporator system
3auto-vapor mechanical compression system
4auto-vapor ejector compression system
5multistage flash system

After taking into consideration of the physical and chemical property of solutions, the desired design conditions, and available utilities, we select the most suitable type of system by utilizing our years of experience and excellent results.
In addition, we can offer designs and manufacturing services that take into careful consideration compactness, energy-efficiency, and automatization.

THREE:

While standard calandria type evaporation systems are widely used as the typical concentration evaporator by the various food and chemical industries, we have delivered many of those systems as finishing concentration evaporators especially for sugar solutions and starch syrups.

THREE:At the distance of nearly a mile from Sudley Castle, and at about a quarter of a mile from the high road that led to Oxford, was a singular kind of quarry or cliff. Its elevation was considerable, and the portion of the hill visible from the road was covered with the heathy verdure which usually springs from such scanty soil; but on passing round to the other side, all the barren unsightly appearance of a half worked quarry presented itself. Huge masses of stone stood firmly as nature had formed them, while others, of a magnitude sufficient to awaken in the hardiest, a sense of danger, hung apparently by so slight a tenure, that a passing gust of wind, seemed only required to release their fragile hold. But the hill had stood thus unaltered during the remembrance of the oldest inhabitant of Winchcombe. Strange stories were whispered respecting this cliff, but as the honour of the house of Sudley, and that of another family equally noble, were concerned in the tale, little more than obscure hints were suffered to escape."By the green wax, but I do! I can never practise my own calling again; and, at any rate, have tried cheating, and lying, and so on, long enoughand what have I got by them?the honestest blockhead in England cannot be worse off than John Oakley! So, as I have said, I shall e'en try what honesty will do! Besides, I owe them something for saving me from the gallows. But I cannot do without drink!and drink, except a beggarly cup of ale or so, is not to be had among themand so, steward, you must give me money."
  • Enables flexible operation with little influence from variations in load and raw solution concentrations because of an adequate amount of solution being held within the system. These systems are also suitable for batch type burning evaporators.
  • Concentrations can be controlled within product specifications by the cascade control using the concentrations of concentrated solution and the raw solution supply and also by the arithmetic control of raw solution concentrations, etc. (Result for sugar solutions: 75±0.2wt%)
  • High-viscosity solutions and solutions that may crystallize can also be utilized by installing a propeller in the evaporator as a forced circulation system.
THREE:"You hemmed, scummy, lousy Radical!"

This is a process example of a device that continuously and simultaneously concentrates two types of waste liquid with a single high-efficiency steam compressor.

THREE:"How many have you got?""I haven't been crying."
  • By evaporating the steam using a mechanical compressor and reusing it, almost no heating steam is alomost required except the time of start-up, so large energy savings can be expected.
  • By combining with a thin film falling heat exchanger that does not raise the boiling point due to the liquid depth, it is possible to utilize the temperature difference of the compressor at the maximum.
  • Since the residence time and heating time are short and the holding amount is small, starting and stopping can be performed in a short time.
  • It will prevent scale adhesion in the can that the evaporator is divided into two parts, and that the supply of the undiluted solution is alternately switched over a fixed period of time to perform heat concentration.